Thread Rating:
  • 0 Vote(s) - 0 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Atv transplant!
#1
Okay I'm starting this so I don't keep posting in the chat section.

As most of you know this past fall my 2004 Arctic Cat 400 4x4 atv let the fly wheel magnets loose and one fell into the stator and broke into chunks and ground down to super fine particals. After pulling the side cover off it was found thT all the magnetic particals had circulated through the motor in the oil and were stick in the bearing, on the crank and rod. Seeing a new Arctic Cat fly wheel was over $400 and if the stator was damaged that was going to be another $600. Figuring there may be further damage and purchasing gaskets and any warren bearings we figured it would be cheaper to go with a new motor from Arctic Cat. For under $2,400 the motor comes 100% complete cover to cover including all internal electronics. All I have to do is re-use my carb and exhaust. Figured I will post up some picks as I get started on this project.

[Image: image-56.jpg]

My new engine I picked up today, took less than 24 hours to get in after ordering yesterday afternoon.
Not Bad For A Girl!

(02-19-2014, 01:01 PM)Diesels n Doos. Wrote: "I know you are, but what am I?"

Reply


Messages In This Thread
Atv transplant! - by KBPLAZA - 03-26-2014, 06:21 PM
RE: Atv transplant! - by KBPLAZA - 03-27-2014, 07:15 PM
RE: Atv transplant! - by irish_redneck - 03-27-2014, 08:32 PM
RE: Atv transplant! - by polarisfan - 03-27-2014, 09:01 PM
RE: Atv transplant! - by eltigre - 03-28-2014, 02:40 AM
RE: Atv transplant! - by KBPLAZA - 03-28-2014, 06:41 AM
RE: Atv transplant! - by polarisfan - 04-03-2014, 06:43 PM
RE: Atv transplant! - by KBPLAZA - 04-06-2014, 07:56 PM
RE: Atv transplant! - by KBPLAZA - 07-07-2014, 06:30 PM
RE: Atv transplant! - by Desy197 - 11-24-2017, 05:50 AM

Forum Jump:


Users browsing this thread: 1 Guest(s)
Facebook Feed

Live Chat